It's a good idea to re-check the bolt tightness after the transmission has warmed up. I last changed the fluid about 30 thousand miles ago. This is the automatic transmission pan after removal. Then you can get to the transmission pan. As always, I tightened the bolts in a cross-pattern, starting at the center of one side and alternating to the center of the opposite side and working around the pan. Synthetic motor oil and transmission fluid have been a significant improvement in car care technology and while they are significantly more expensive than conventional oils and fluids, they can coax more life and better performance from your vehicle. I put the magnet back in the pan so I wouldn't forget it when it's time to re-install the pan.
One additional point: Make sure you use the recommended fluid. Normally I would start by adding 5 quarts and then running the engine for a few minutes, while shifting the transmission through all the gears. When you purchase it, just ask at the parts store and. Maki, Editor Start: Everybody knows that it's important to regularly change the oil in their car, but many people are not aware of the other fluids that need to be changed periodically, such as coolant, differential fluid, and automatic transmission fluid. Cleaning The Transmission Pan: I removed the donut-shaped magnet from the pan and wiped off the sludge with a paper towel. I tried to apply that force to the wrench. Then, following the shop manual, I backed off the screw two full turns, and I tightened the locking nut a lot more than 72 inch-pounds, I'll say.
Delivers maximum protection for towing and other severe-duty applications. Otherwise you will ruin your Chrysler transmission to save a few dollars. Using a small garden sprayer, I sprayed some mineral spirits paint thinner into the pan and brushed it with a parts cleaning brush. Here I've arranged the filter and gasket as they would fit on the vehicle, as viewed from above. If you have one of the newer 4-speed models of the Dodge Caravan, it is highly recommended that you use the best available transmission fluid to get the longest possible life out of your minivan's transmission.
. Remember, these bolts thread into aluminum, go easy. It improves fuel efficiency, reduces transmission temperatures by 20 to 50 degrees F and increases transmission life. A cork gasket often can benefit from a thin layer of gasket sealer or adhesive, especially to keep it in place while you're trying to start those first few bolts. Note the brownish-looking bolt near the upper-right. I used a 14mm wrench because it fit tighter. Shop online, find the best price on the right product, and have it shipped right to your door.
How Much Fluid: I measured how much fluid I caught in my big plastic basin and it came to 6 quarts. Consider that a gallon of water weighs about 8 pounds, so 6 pounds is as heavy as 3 quarts of water. Finding this little metal ball in the pan was like finding gold for me. Here at Advance Auto Parts, we work with only top reliable Automatic Transmission Fluid product and part brands so you can shop with complete confidence. The band is adjusted by loosening the locknut and turning the screw. Schedule B - Severe service, which includes vehicles that often tow heavy trailers or plow snow, and several other factors like frequent short trips, extended engine idling, driving at high speeds in hot weather, driving off-road, driving in dusty conditions, etc. Dexron has long since passed its prime, and modern transmissions require modern fluids, which more refined properties.
Some of our top Automatic Transmission Fluid product brands are , and. The service manual says to tighten these screws to 35 inch-pounds. We started seeing shudder at 55+ mph. Remove the big black skid plate thing. Use a hammer and dolly to flatten them out. They are usually not used for autos.
My Chrysler factory service manual says to tighten this screw to 72 inch-pounds, which is 6 foot-pounds. Auto Transmission Fluid has no business in these gearboxes. There was a black rubber gasket around the mating surface. You can buy at any automotive store. In Dodge's desire for more performance and better fuel economy, Dodge has been developing innovative transmissions on a regular basis.
The exhaust pipe runs beneath the front of the transmission pan, but all of the bolts are accessible. Many vehicles with manual transmissions do not have a dipstick and their fluid level should be checked by an automotive technician as the car will likely need to be hoisted on a lift. Then I laid the gasket on the pan and inserted the bolts through the gasket. When the fluid had slowed, I removed the other bolts and carefully lowered the pan while pouring the fluid into the catch basin. Dexron is not a universal fluid. I don't have enough expertise in automatic transmissions to predict exactly what would happen.